Page 22 of 26
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Tue Aug 20, 2019 2:57 pm
by Sandblaster
Ok... Here's a quickie update.
The bike runs amazing.
Jetting was tough due to the unusually small jet sizes required with this exact set up.
In fact I'm waiting for more jets to come in..
In the mean time I have prepped another carb just to be safe
I have a few loose ends to tie up but nothing major.
The graphics should be here later this week or early next.
I won't be able to post any pics until after the magazine comes out from here on out
I have 4 gallons of fuel ran through it so it could be ready in a few hours once I get the graphics here.
Right now we are waiting for Daryl (MXA Editor) to give us a exact time and date for the photo shoot and test ride.
It's getting very exciting...
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Fri Aug 23, 2019 6:52 pm
by Sandblaster
Nothing says BLING!!!! like a TSR 2 piece clutch cover!!!
- 20190822_131812_resized.jpg (865.95 KiB) Viewed 12626 times
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Fri Aug 23, 2019 10:31 pm
by Sandblaster
On KX Guru Racing facebook, Ben posted a pic of his..
- BEN PROBST COVER BLUE ANNODIZED.jpg (46.46 KiB) Viewed 12624 times
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Sat Aug 24, 2019 1:23 pm
by Sandblaster
Quickie mock up...
- 69160431_2509693349077096_5754891211794022400_n.jpg (151.55 KiB) Viewed 12619 times
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Mon Aug 26, 2019 2:33 pm
by Sandblaster
I'm relocating the vent for the electric starter from on the electric starter to the air box.
- KX RURU RACING ELECTRIC STARTER VENT RELOCATION SETUP.jpg (241.32 KiB) Viewed 12589 times
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Tue Aug 27, 2019 3:02 am
by Sandblaster
Waiting for my Supercooler cover to get back from Powder coating
- Super cooler.jpg (15.69 KiB) Viewed 12582 times
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Thu Sep 05, 2019 3:18 am
by Sandblaster
Ok... I guess this will have to do...
- 20190904_125932_resized.jpg (298.74 KiB) Viewed 12529 times
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Sun Sep 08, 2019 4:26 am
by Sandblaster
The graphics were finalized and approved...
- ktx.png (69.02 KiB) Viewed 12518 times
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Sun Sep 08, 2019 5:55 pm
by Sandblaster
- parris.png (67.15 KiB) Viewed 12516 times
Re: KX GURU Racing kx500 Engine in a 2016 KTM 250 SX PUMPKIN SEEDS BUILD
Posted: Sat Sep 14, 2019 7:46 pm
by Sandblaster
Put it together, take it apart... Modify it, put it back together... take it apart... Modify it, put it back together... take it apart... Modify it, put it back together... take it apart... Modify it, put it back together...
I have never had a project that I did this much fussing over
Just finished up the starter vent relocation
- 20190914_102127_resized.jpg (338.33 KiB) Viewed 12481 times
- 20190914_102138_resized.jpg (322.58 KiB) Viewed 12481 times
- 20190914_102142_resized.jpg (250.24 KiB) Viewed 12481 times